Closed cell spray foam removal in Newport Shrops
Specialist extraction for lofts, roofs and cavity walls across Shropshire.
We carry out closed cell spray foam removal in Newport Shrops for homeowners who cannot sell, remortgage or insure a property because rigid foam was sprayed onto roof timbers. Closed cell foam extraction Shropshire wide is our core trade, not a sideline. We have been removing spray foam since 2021, and we work to a fixed price agreed before we start. Most lofts are cleared in one to two days.
What closed cell spray foam removal in Newport Shrops involves
Closed cell spray foam is the rigid, dense foam that sets like plastic and bonds hard to roof felt, battens and rafters. Removing it is not a case of pulling it off by hand. We cut the foam into manageable sections with a reciprocating saw and an oscillating multi-tool, then lift it away without tearing the timbers underneath. An industrial vacuum with a dust extraction unit captures the airborne particles as we go, so your loft stays as clean as we can make it.
Most people in Newport Shrops call us for one of three reasons: a mortgage lender has refused to lend on a foam-insulated roof, a surveyor has flagged reduced loft ventilation and condensation, or the foam has started to trap damp against the timber. If you have searched for closed cell spray foam removal Newport Shrops near me and found only national call centres, we are the local team that actually turns up. We assess the roof structure first, then quote.
Why homeowners clear closed cell foam
Rigid foam solves one problem and creates three more. Clearing it restores the roof structure, the ventilation path and the property's mortgageability.
Unblocks your mortgage
Lenders on the Shropshire panel routinely decline properties with closed cell foam on the underside of the roof. Once the foam is out and the timbers are inspected, your lender's valuer can sign the property off. We provide photographic evidence of the cleared roof deck for your file.
Stops trapped condensation
Closed cell foam seals the roof deck, so moisture from bathrooms and kitchens has nowhere to go. It condenses on the cold side of the foam and soaks into rafters. Removing the foam restores the ventilation gap between the felt and the insulation line, and damp readings drop within weeks.
Protects roof timbers
Wet timber rots. We have opened roofs in Newport Shrops where 40mm of rafter had softened to the point of crumbling after eight years under foam. Extraction lets us inspect every rafter, treat what is salvageable and replace what is not before the roof needs a full re-roof.
Restores loft access and storage
Foam sprayed across the rafters turns a usable loft into a sealed box. Once we have cleared it, you get the space back for storage, a loft conversion survey or a straightforward re-insulation with mineral wool or plasterboard and vapour barrier. Most lofts are fully usable again within 48 hours.
How our removal process works
Five stages, from first phone call to a cleared roof deck. You get a fixed price after the survey, and we tell you on the day what we have found.
Survey and quote
We visit your property in Newport Shrops, measure the roof area, check the foam thickness and note any timber damage or damp. You get a fixed written price the same week, with no charge for the survey. Most surveys take 30 to 45 minutes.
Protect and prepare
On the first morning we lay dust sheets, seal the loft hatch and set up the dust extraction unit. Our technicians wear full PPE including respirator, gloves and coveralls. If you are staying in the house, we keep the working area sealed off so no foam dust reaches your living space.
Cut and extract foam
We cut the closed cell foam into sections using a reciprocating saw and an oscillating multi-tool, working rafter by rafter. The industrial vacuum takes the debris away as it falls. A typical three-bedroom semi in Newport Shrops takes one to two days to clear completely.
Inspect and treat timbers
With the foam gone we inspect every rafter and batten for rot, damp or insect damage. Sound timbers get a preservative treatment. Any rafter that has lost more than a quarter of its section is replaced and sistered by our carpenter before we close up.
Clear up and hand over
We bag and remove all foam waste, vacuum the loft floor and photograph the cleared roof deck for your records. You get a written summary of what we found and what we did, plus a 5-year workmanship warranty on the removal itself.
Five years clearing rigid foam roofs
We have been removing spray foam since 2021 and closed cell foam is the material we handle most. Our technicians are trained in dust-controlled demolition and work to BBA approved methods for insulation removal. We are CHAS accredited, Constructionline registered and SafeContractor approved, so we can work on domestic and commercial sites without paperwork delays. Every job is surveyed by someone who has personally cut foam out of a roof, not a salesperson reading from a script. We know the difference between Isothane, Soudal and EnviroFoam products on sight, and we know which ones come away cleanly and which fight back.
- Closed cell foam specialists since 2021, with hundreds of Shropshire roofs cleared
- CHAS accredited, Constructionline registered and SafeContractor approved
- Dust-controlled removal using industrial vacuum and dust extraction unit
- Timber inspection and rot treatment included in every removal quote
- Fixed pricing agreed after survey, with no day-rate surprises
Why choose our closed cell spray foam removal in Newport Shrops
We are a local removal team, not a national lead-generation site. You speak to the people who will be in your loft, and you get a fixed price before we start.
Local, not a call centre
We are based in the Newport Shrops area and cover Shropshire, Telford and Wrekin. When you ring 03335672543 you speak to someone who can be at your property the same week. No call handlers, no subcontracted crews from three counties away.
Fixed price after survey
You get one price for the whole job: survey, removal, timber treatment, waste disposal and clean-up. If we find more foam than the survey showed, we absorb it. The figure we quote is the figure you pay, and it is valid for 90 days.
Mortgage-ready paperwork
Lenders and valuers want evidence. We photograph the cleared roof deck, note the condition of every rafter and provide a written removal summary you can forward to your broker. That documentation has helped clients complete remortgages across Shropshire.
Dust-controlled working
Closed cell foam removal creates fine airborne debris. We use an industrial vacuum and dust extraction unit on every job, seal the loft hatch and wear full PPE. If you search for closed cell foam removal near me Newport Shrops, you will find plenty of quotes. We are the ones who leave your house clean.
What our closed cell foam removal includes
Every removal quote covers the full job from survey to clean-up. There are no hidden extras for waste disposal, timber treatment or documentation. If we find something unexpected in the roof, we deal with it and tell you what we found.
What's Included
Full roof survey
We measure the foam coverage, check moisture levels in the timbers and photograph the roof deck before we quote. The survey takes 30 to 45 minutes and there is no charge for it.
Mechanical foam extraction
Closed cell foam is cut into sections with a reciprocating saw and oscillating multi-tool, then lifted clear rafter by rafter. An industrial vacuum captures debris as it falls, keeping the loft and your home clean.
Timber inspection and treatment
With the foam gone we inspect every rafter and batten. Sound timber is treated with preservative. Any rafter that has lost more than a quarter of its section is replaced and sistered before we finish.
Waste disposal
All removed foam is bagged and taken away by licensed waste carriers. Where the material allows, it is separated for recycling. You do not need to hire a skip or arrange disposal yourself.
Photographic evidence pack
We photograph the cleared roof deck, note the condition of each rafter and provide a written removal summary. This is the documentation your lender, valuer or surveyor will ask to see.
5-year workmanship warranty
The removal itself is covered by a 5-year workmanship warranty. If any area we cleared shows a problem caused by our work, we come back and put it right at no cost to you.
Problems closed cell foam removal near me Newport Shrops solves
Rigid foam causes a predictable set of problems. Here are the ones we see most often in Newport Shrops, and what we do about each.
Mortgage lender refuses to lend on a foam-insulated roof
Your sale or remortgage stalls, and buyers walk away once the survey flags the foam. The longer it sits, the more the property is discounted.
We remove the foam, inspect the timbers and provide a photographic evidence pack with a written summary. Lenders on the Shropshire panel accept this documentation, and most clients complete their sale or remortgage within weeks of the work finishing.
Condensation forming on the underside of the roof deck
Moisture has nowhere to escape, so it condenses against the cold felt and drips onto the timbers. Left alone, it soaks the rafters and starts rot.
Closed cell foam seals the roof deck and blocks the ventilation path. We cut it out, restore the gap between felt and insulation line, and check moisture readings in the timbers. Damp readings normally fall within a few weeks of removal.
Roof timber rot hidden behind the foam
Wet timber softens and loses strength. We have opened roofs where 40mm of rafter had crumbled after eight years under foam, and the homeowner had no idea.
Extraction lets us inspect every rafter. We treat sound timber with preservative and replace any rafter that has lost more than a quarter of its section. You get a written note of what we found and what we replaced.
Reduced loft ventilation and rising heating costs
A sealed roof deck traps heat and moisture in the wrong places. The loft overheats in summer, the roof space stays damp in winter, and your heating bills creep up.
Once the foam is out, we restore the ventilation path and can re-insulate with mineral wool or a breathable board system. Most clients see the loft return to a normal temperature range within a season.
When to book closed cell foam removal
You are selling a house in Newport Shrops and the buyer's surveyor has flagged spray foam on the roof deck.
We survey within the week, quote a fixed price and clear the foam in one to two days. You get the photographic evidence pack to pass to the buyer's solicitor and lender.
The sale proceeds without a five-figure discount being demanded for the foam.
Your loft was sprayed with closed cell foam years ago and you now want to convert it into a habitable room.
We remove the foam from the rafters, inspect the timbers and restore the roof structure so your builder can work with clean, sound timber and a proper ventilation gap.
The loft conversion can be signed off without the foam being flagged at building control stage.
You have noticed damp patches on the ceiling below the loft, or the rafters feel cold and wet to the touch.
We assess the roof, measure moisture in the timbers and remove the foam that is trapping condensation. Any rot we find is treated or replaced before we finish.
The roof space dries out, the damp patches stop spreading and the timbers stabilise.
You have bought a property with foam insulation and your lender is holding back the final tranche of the mortgage.
We carry out the removal to a fixed price and provide the documentation your lender needs: photographs of the cleared deck, a written summary and a 5-year workmanship warranty.
Funds are released and the property is mortgageable again.
Tools and methods we use
Tools & Equipment
Reciprocating saw
Cuts the rigid foam into liftable sections along the rafters. We use fine-tooth blades and control the depth so the timber underneath is not scored.
Oscillating multi-tool
Gets into corners, around nails and into tight attic spaces where a full saw will not fit. Essential for foam bonded to battens and trusses.
Industrial vacuum and dust extraction unit
Captures airborne foam particles at the cutting head. This is what keeps the dust out of your living space and off the loft floor.
Dry ice blasting machine
Removes foam residue from delicate or historic surfaces without abrasion. Used where mechanical cutting would damage the substrate.
Sand blasting equipment
Strips foam residue from masonry and concrete on commercial walls and warehouse structures where the foam has bonded hard.
PPE: respirator, gloves, coveralls
Full protective kit for every technician on site. Foam dust is an irritant, and we do not cut without it.
Methods
BBA approved removal methods
We follow BBA approved practice for insulation removal, which means controlled cutting, dust capture and documented inspection of the substrate. It is the standard lenders and surveyors recognise.
Rafter-by-rafter extraction
Rather than clearing a whole roof in one pass, we work one rafter bay at a time. This keeps the structure stable, lets us inspect as we go and means we can stop immediately if we find serious rot.
Dust-controlled demolition
Every cutting point is paired with extraction. We seal the loft hatch, sheet the floor below and run the extraction unit for the full shift. It is slower than cutting dry, and it is the reason our clients can stay in the house.
Timber moisture testing
We take moisture readings on rafters before, during and after removal. Readings above 20% indicate active damp, and we will not close up until the cause is addressed.
How closed cell foam removal runs in Newport Shrops
Newport Shrops sits in Shropshire, and the housing stock here shapes how we work. A large share of the properties we survey are Victorian and Edwardian terraces and semis around Newport Town Centre, plus 1960s and 1970s estates in Church Aston and Edgmond. Older roofs have thinner rafters and no modern vapour barrier, so foam sprayed onto the deck traps moisture fast. We see the worst rot in these older properties, often within six to eight years of the foam going in. Winter here is damp and cold, with frosts from November through March, and that drives condensation against the cold felt. If you have been looking for spray foam closed cell removal from lofts Newport Shrops, we handle the whole job: survey, extraction, timber treatment and waste disposal, with a fixed price agreed before we start.
Service Areas
Mostly older terraces and townhouses with shallow roof pitches. Access is often through a narrow loft hatch, so we use compact cutting tools and a small extraction unit.
A mix of 1960s semis and larger detached homes. Foam was commonly sprayed onto the roof deck here in the 2010s, and we see a high rate of trapped condensation.
Rural properties with larger roof spans and, in some cases, listed status. Dry ice blasting is often the right method where the timber cannot take mechanical cutting.
Newer estates with modern trussed roofs. Foam here is usually thinner and comes out faster, often in a single working day.
Local Considerations
Damp Shropshire winters with regular frosts
Cold roof decks attract condensation, and foam traps it against the timbers. We schedule removals through autumn and winter so the roof can dry out before spring.
Older roof structures with thin rafters
Victorian and Edwardian timbers are often 75mm to 100mm deep. We cut more slowly and inspect each rafter, because these are the ones that rot first.
Limited loft access in terraced housing
Narrow hatches and low headroom mean we use oscillating multi-tools and compact vacuums rather than full-size saws, which adds a few hours to the job.
Rural properties with no neighbouring access
In villages like Edgmond and Forton we plan waste removal carefully, since there is often no easy route for a skip. We bag and carry foam out in stages.
Mortgage declined, foam cleared, sale completed
A three-bedroom semi in Church Aston had closed cell foam sprayed across the entire roof deck in 2015. In 2026 the owner tried to sell and the buyer's lender declined the mortgage outright. The surveyor noted reduced ventilation and damp staining on two rafters.
We cleared 42 square metres of foam in two days, treated the timbers and replaced one rafter that had lost a third of its section. Moisture readings dropped from 24% to 14% within three weeks. The lender released funds and the sale completed.
Maintenance & Follow-up
We advised the new owner to keep the loft hatch vented and re-insulate with mineral wool between the joists, leaving the roof deck clear. A moisture check each autumn keeps an eye on the timbers.
A homeowner in Newport Town Centre had a damp patch spreading across the landing ceiling. The loft was sealed with closed cell foam and there was no ventilation gap. Two rafters were wet to the touch and one showed early rot.
We removed the foam from the affected bays in a single day, treated the rafters and restored the ventilation path. The damp patch stopped spreading within a fortnight and the ceiling was redecorated. The homeowner re-insulated the loft floor separately.
Maintenance & Follow-up
We fitted a vented loft hatch and recommended leaving the roof deck clear. An annual check of the timbers each autumn is enough to catch any recurrence early.
A couple in Edgmond wanted to convert their loft but the builder would not quote until the closed cell foam was gone. The foam covered 55 square metres of roof deck and had bonded hard to the battens. Access was tight through a small hatch.
We cleared the foam over three days using oscillating multi-tools and dry ice blasting on the historic timbers. All rafters were sound after inspection. The builder was able to start the conversion the following month with a clean, ventilated roof structure.
Maintenance & Follow-up
The conversion now includes a vapour barrier and mechanical ventilation, so the roof deck stays dry. We advised a moisture check at the first-year anniversary of the build.
How much does closed cell spray foam removal cost in Newport Shrops?
Typical 2026 pricing in this area runs from £1,800 for a small two-bedroom loft to £4,500 for a large detached roof, including waste disposal and timber treatment. The main variables are roof area, foam thickness and how much rafter damage we find. We survey first and give you a fixed price, so the number you agree is the number you pay.
Can you remove closed cell foam from my loft in Newport Shrops Shropshire?
Yes. We remove closed cell foam from lofts, roof decks, attic spaces and cavity walls across Newport Shrops and the wider Shropshire area. We cut the foam out mechanically rather than scraping it, which protects the timbers underneath. Most lofts are cleared in one to two working days, and we photograph the cleared roof deck for your records.
Is closed cell foam removal worth it in Newport Shrops?
If a lender has declined your mortgage or a surveyor has flagged the foam, removal is usually the only route to a sale. A full removal typically costs £1,800 to £4,500, while the discount a buyer demands for a foam-insulated roof often runs to five figures. For most homeowners in Newport Shrops, the removal pays for itself at the point of sale.
How long does closed cell spray foam removal take in Newport Shrops?
A standard three-bedroom semi takes one to two days from set-up to clean-up. Larger detached roofs or lofts with heavy timber damage can run to three days. We book most jobs within two to three weeks of survey, and we tell you the expected duration in writing before we start so you can plan around it.
Certifications and reviews
Certifications
Reviews
Cleared closed cell foam from our loft in two days after our mortgage was declined. They photographed everything for the lender and the sale went through. Fixed price, no extras, and they cleaned up properly.
We had damp on the landing ceiling for two years. They found the foam was trapping condensation, removed it and treated the rafters. The damp has not come back. Genuinely knowledgeable about older Shropshire roofs.
Booked them for a loft conversion clearance in Edgmond. Tight access, historic timbers, and they handled it carefully with dry ice blasting. The builder started the following month with no issues.
Surveyed on Tuesday, quoted on Thursday, foam out the following week. They explained exactly what they would do and stuck to the price. Would recommend to anyone in Newport Shrops with spray foam problems.
Related Services
Spray Foam Removal near me
If you need a removal team close to home, we cover Newport Shrops and the surrounding Shropshire villages. Same survey process, same fixed pricing, and we can usually be on site within two to three weeks of your call.
Spray Foam Removal near mesame day Spray Foam Removal
For urgent cases, such as a lender's deadline or a house sale about to fall through, we hold limited same-day slots for small loft sections. Ring 03335672543 early and we will tell you honestly whether we can fit you in.
same day Spray Foam Removal24/7 Spray Foam Removal
Commercial clients and landlords sometimes need out-of-hours working so a building stays open. We run evening and weekend shifts for closed cell foam removal on commercial roofs, with the same dust-controlled methods and fixed pricing.
24/7 Spray Foam RemovalResidential Spray Foam Removal
Most of our closed cell work is domestic: semi-detached and detached houses across Newport Shrops with foam sprayed onto the roof deck. We protect your home, seal the loft hatch and clear up fully before we leave.
Residential Spray Foam RemovalCommercial Spray Foam Removal
We remove closed cell foam from commercial roofs, warehouses and agricultural buildings across Shropshire. Work is planned around your operating hours, and we provide the RAMS and certification your site manager needs before we start.
Commercial Spray Foam Removalloft spray foam removal
Loft foam removal is the job we do most. We cut the closed cell foam away from rafters and battens, inspect the timber and restore the ventilation path so the loft can be re-insulated properly or converted.
loft spray foam removalroof spray foam removal
Foam sprayed directly onto the underside of the roof deck traps moisture against the felt. We remove it rafter by rafter, check for rot and provide photographic evidence of the cleared deck for your lender or surveyor.
roof spray foam removalAttic spray foam removal
Attic spaces with restricted access need smaller cutting tools and careful dust control. We use oscillating multi-tools and a compact industrial vacuum to clear attic foam without damaging the roof structure or the ceiling below.
Attic spray foam removalspray foam insulation removal
We remove all types of spray foam insulation, not just closed cell. If you are unsure which product you have, we identify it at survey and quote accordingly, whether it is Isothane, Soudal or an unbranded foam.
spray foam insulation removalopen cell spray foam removal
Open cell foam is softer and comes away more easily than closed cell, but it still traps moisture. We remove it, inspect the timbers and restore ventilation, often in a single day for a standard loft.
open cell spray foam removalmortgage lender spray foam removal
When a lender refuses to release funds because of spray foam, we provide the removal and the paperwork. You get photographs of the cleared roof deck, a written summary and a 5-year workmanship warranty to send to your broker.
mortgage lender spray foam removalinsulation removal service
Beyond spray foam, we clear old mineral wool, vermiculite and contaminated insulation from lofts across Newport Shrops. It is often booked alongside closed cell removal so the loft can be re-insulated to current standards.
insulation removal serviceinsulation assessment
Not sure whether the foam needs to come out? We assess the roof, measure moisture levels in the timbers and tell you plainly whether removal is necessary or whether ventilation improvements would solve the problem.
insulation assessmentdry ice blasting spray foam removal
For delicate surfaces and listed buildings, dry ice blasting removes foam residue without abrasive damage. We use it where a roof structure or historic timber cannot take mechanical cutting, then finish with a full vacuum clean.
dry ice blasting spray foam removalCavity wall spray foam removal
Foam injected into cavity walls can bridge the damp-proof course and cause penetrating damp. We remove it using specialist extraction equipment, then assess whether the cavity needs a new insulation product installed.
Cavity wall spray foam removalsand blasting spray foam insulation removal
On masonry and concrete surfaces where foam has bonded hard, sand blasting equipment strips the residue back to a clean substrate. It is a controlled method we use on commercial walls and warehouse structures.
sand blasting spray foam insulation removalthermal spray foam removal
Thermal foam and high-density variants need slower cutting speeds to avoid heat build-up and tool damage. We adjust our method at survey and use the right blade and extraction setup for the product on your roof.
thermal spray foam removalenvironmentally friendly insulation removal
All foam waste we remove is bagged and disposed of through licensed waste carriers, with recycling where the material allows. We keep the working area sealed so no foam dust escapes into your home or the surrounding area.
environmentally friendly insulation removalWarehouse spray Foam removal
Large-span warehouse roofs with closed cell foam need a planned programme, not a one-day job. We phase the work around your operations, provide full RAMS and certification, and keep each bay clear and safe as we go.
Warehouse spray Foam removalBook your closed cell spray foam removal in Newport Shrops
Ring 03335672543 and we will book a survey at your property, usually within the same week. You get a fixed price, a dust-controlled removal and a 5-year workmanship warranty. We have been clearing foam roofs since 2021.